Building Maintenance Technician
Vanderbilt University - Nashville, TN
Apply NowJob Description
The Building Maintenance Technician is part of the Facilities department at Vanderbilt University and is a key individual responsible for the ongoing maintenance and repair of a building or area. Building Maintenance Technicians need to have a good knowledge of building skills, including HVAC, plumbing, drywall installation, painting, and general building repair. The position reports directly to a Zone Manager. This is a great opportunity for candidates with a mechanical background or aptitude looking to gain experience in a wide range of facilities and trades skills, and who wants to expand their experience as a craftsman or technician. About the Work Unit: Plant Operations provides facilities support for all construction, renovation, and routine maintenance of University Central space and facilities; housekeeping services for approximately 5.8 million square feet of academic, administrative, residential, and recreational space; grounds care for 330 acres that are a registered arboretum; turf care for athletic fields; and utilities for the University Central and the Medical Center. Key Functions and Expected Performance: * Change filter in dorm room unit * Check chilled water pressure in building * Check Steam pressure at PRV station in building * Check run status on air handling unit * Check alarm on VFD * Investigate water leaks * Change air filters in AHU * Grease pump/motor bearings * Check a steam trap for proper operation * Check/prime AC drain trap * Assist HAR Tech in pulling motors on equipment * Assist Tech with condensate pump system repairs * Clean AHU coils/air intakes * Change out thermostats * Check discharge air temps on HVAC equipment * Clean and organize work areas, including mechanical/electrical rooms' parts storage areas * Plunge sink and toilet (snaking) * Replace shower curtain rods * Tighten toilet seat * Replace wax ring on toilet and reset toilet * Rebuild flush valve * Use small sewer machine * Change batteries in auto flush valves * Use pro-press to install piping and valves * Change out fire extinguishers (including record keeping) * Test fire extinguishers (including record keeping) * Clean out drains * Caulk sinks and vanities * Change out toilet tank float/flush assemblies * Change out water stop valves * Help w/winterization at Stadium * Help w/installation of shutoff valves on water mains to each floor of buildings * Help plumber w/various plumbing/piping repairs * Assist plumber w/repair or replacement of water heaters * Minor piping repairs to fix leaks * Replace ceiling tile * Replace rubber base * Replace carpet and carpet squares * Hang pictures/bulletin/dry erase/chalk boards * Cut and install small drywall pieces/mud * Patch holes and nail holes * Help carpenter lay ceramic floor tile and grout * Respond to roof leak calls and locate leak * Change out/install door sweeps * Install/replace door stops * Repair tracks on sliding doors * Minor dorm furniture repairs * Assist carpenter w/assembling trash cans/benches & setting them * Repair brackets for wall shelving * Replace lamps and ballasts in any fixture * Replace/upgrade fixtures * Replace receptacles and switches * Reset small amperage circuit breakers * Proper handling/disposal of lamps and ballasts * Organize bulb supply and spent bulb storage locations * Use Volt-Ohm Meter to check voltage/current * If trained, use man lift/boom lift/scissor lift and single man lift/bucket truck for various repairs * String lights and drop cords in tents for special events * Assemble scaffolding/adjustable ladders to work on various lighting repairs * Assist electrician on conduit runs/wire pulls * Hand banners on street light poles * Set up and monitor personal work order query * Process daily work order time sheet * Operate vehicle/golf cart and perform operator level maintenance * Other duties related to classification Supervisory Relationships: This position does not have supervisory responsibility, this position reports administratively and functionally to the Zone Manager. Education and Certifications: * High School Graduate or GED is required * Valid driver's license is required * Ability to work safely around equipment Experience and Skills: * Strong communication skills * Able to stand, stoop, crawl, work on elevated surfaces and be in awkward positions for extended periods of time. * Push, pull, lift and carry at least 50 pounds. * Able to work in various weather conditions * High work ethic * Ability to effectively communicate and follow written and oral instructions is Preferred * Ability to: change light bulbs, ballasts, fixtures, switches/plates, HVAC filters, thermostats, hang pictures, tighten screws on hardware, lubricate hinges and closures. * Touch up paint as needed. * Simple plumbing repairs. * Perform preventive maintenance on equipment.
Created: 2024-10-22